700R4 tv cable adjustment

POST INSTALLATION ADJUSTMENT. How to adjust the TV Cable (throttle valve) cable for your 700R4. Step Obtain a cable that is designed for. Adjusting 700RTV Cable - Hot Rod Forum. Need help adjusting 700rtv cable - Hot Rod.

TV cable adjustment and lengths of cable. The throttle valve cable controls transmission pressure. The final step is to adjust the throttle valve cable. Have look at all sorts of sites.

I have read all the info from BTO and TCI. Either they had no idea, were convinced that it was just a kickdown cable , or were told that exact adjustment was not critical. Proper installation of the throttle valve cable on Factory and after-market carburetors or fuel injections. Throttle valve cable adjustment instructions.

What this means, in simple terms, is that TV pressure that is too low, will produce main line pressure that is also too low, and will eventually burn the transmission clutches. Yes, the correct Geometry is needed for proper adjustment. Help with setting the 700rtv cable. PART ONE - EXPLANATION OF STOCK TV CABLE SYSTEM.

GM vehicles equipped with the 700Rautomatic transmission use a throttle valve cable to control the shift characteristics of the transmission. Shift Kits, Rebuild Kits and more! Low Prices, Fast Free Shipping.

Getting a rebuilt 700rand want to adjust the cable correctly. Let go of the adjustment tab. Move the accelerator linkage until it reaches the full throttle stop. How do you properly adjust the tv cable for the 700r?

Do I leave the throttle shut and pull the slack out of the cable ? I know that if the cable is too tight the trans will shift hard while too soft will give sloppy shifts. GM 3Ram Jet TV Made EZ System. R-KICKDOWN THROTTLE Bracket. Kickdown Bracket for 700R4. There lots of adjustment on the cable and on the housing at both ends.

Here is the installed kick down cable. The kick down is installed you can move onto the throttle cable , which basically follows the same procedure as the kick down, but is a little easier. PLEASE READ THIS: I am not a transmission repairman. I use a 700Rin my truck and have accumulated the following information that might help you. The cable regulates internal line pressure, shift points, and downshifts, so proper installation and adjustment is critical.

These brackets are designed to work with GM factory cables. But then why would it-the cable isn’t at fault. Re: 700rGovernor Adjustment The accumulator has nothing to do with when it shifts, just how firmly it shifts.

This cable must be adjusted properly or the transmission will fail. This is the ONLY way of assuring correct adjustment. RTorqe Converter Lock Up Wiring. TH3Conversion to 700R4.

EDELBROCK installation how to GM. TV kickdown cable adjustment. In order to get my 700rto play nice with the EZ-EFI, I bought the FAST adaptors to maker the geometry correct. When I went to set the cable , it extends so far, it almost completely disengages the sheath.

If you look, you can see two allen head bolts in the side of the manifold. PATC Sells TV Cables for 700R, 200-4R, AO C 72 46RE, 47RE, 48RE and others. Lokar TV Cables and OEM Type Cables. The easy-to-use design is constructed of steel and comes with all the necessary parts for a clean install.

Having it shift softly and early is what burns them up. If you adjust it incorrectly you will burn up the transmission. Secon the governor also has an effect that you need to take into account.

Improper adjustment can cause the tranny to slip.

I switched to a 4lwith a modified stock valve body which made it full manual. I did my 700rlike jthomas stated.

IIRC you pull wide open and pull the cable all the way. It should have a click type adjustment in the bracket for fine adjustment after you set the cable length. TV (Detent) Cable Adjustment. The following assumes correct throttle linkage geometry used in a fuel injected or application where the transmission was used from the factory.

WARNING: PERMANENT DAMAGE WILL OCCUR, IF THE T. CABLE IS NOT ADJUSTED PROPERLY, OR HOOKED UP.

THE DAMAGE WILL OCCUR WITHIN A FEW FEET OF DRIVING THE VEHICLE! IF NOT ADJUST PROPERLY YOU WILL HAVE TRANSMISSION FAILURE!